|
345014401
|
0524200
|
2020-11-06
|
1639 GIBSON DR., ELK GROVE VILLAGE, IL, 60007
|
|
| Inspection Type |
Planned
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2020-11-06
|
| Emphasis |
L: FALL, P: FALL
|
| Case Closed |
2021-06-09
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19260100 A |
| Issuance Date |
2021-02-24 |
| Current Penalty |
1000.0 |
| Initial Penalty |
2341.0 |
| Final Order |
2021-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.100(a): Employees were not protected by protective helmets while working in areas where there was a possible danger of head injury from impact, or from falling or flying objects, or from electrical shock and burns: a) On November 6, 2020, an employee was not wearing protective helmets where there was a possible danger of head injury from falling objects. No abatement certification or documentation is required for this item. |
|
| Citation ID |
01002 |
| Citaton Type |
Serious |
| Standard Cited |
19260501 B13 |
| Issuance Date |
2021-02-24 |
| Current Penalty |
4000.0 |
| Initial Penalty |
4096.0 |
| Final Order |
2021-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
3 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(13): Each employee(s) engaged in residential construction activities 6 feet (1.8 m) or more above lower levels were not protected by guardrail systems, safety net system, or personal fall arrest system, nor were employee(s) provided with an alternative fall protection measure under another provision of paragraph 1926.501 (b): a) On November 6, 2020, employees engaged in roofing activity were not protected from fall hazards while working at an elevation of approximately 15 feet above the ground. No abatement certification or documentation is required for this item. |
|
| Citation ID |
01003 |
| Citaton Type |
Serious |
| Standard Cited |
19261053 B04 |
| Issuance Date |
2021-02-24 |
| Current Penalty |
1000.0 |
| Initial Penalty |
2341.0 |
| Final Order |
2021-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
2 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.1053(b)(4): Ladder(s) were used for purposes other than the purpose for which they were designed: a) On November 6, 2020, the extension ladder was used by two employees simultaneously to access and/or egress the roof. No abatement certification or documentation is required for this item. |
|
| Citation ID |
02001 |
| Citaton Type |
Other |
| Standard Cited |
19260503 B01 |
| Issuance Date |
2021-02-24 |
| Abatement Due Date |
2021-03-29 |
| Current Penalty |
0.0 |
| Initial Penalty |
0.0 |
| Final Order |
2021-03-15 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.503(b)(1): The employer did not verify compliance with paragraph (a) of this section by preparing a written (training) certification record including the name or other identity of the employee trained, the date(s) of the training, and the signature of the person who conducted the training or the signature of the employer: a) On or about November 6, 2020, the employer did not maintain records or certification of fall protection training for employees exposed to fall hazards. In accordance with 29 CFR 1903.19(c), abatement certification is required for this violation (using the CERTIFICATION OF CORRECTIVE ACTION WORKSHEET). |
|
|
|
342276367
|
0524530
|
2017-04-25
|
20 COTTONWOOD DRIVE, GLEN CARBON, IL, 62034
|
|
| Inspection Type |
Planned
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2017-04-25
|
| Emphasis |
L: FALL, P: FALL
|
| Case Closed |
2017-06-13
|
Related Activity
| Type |
Inspection |
| Activity Nr |
1238832 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19261053 B01 |
| Issuance Date |
2017-05-16 |
| Current Penalty |
0.0 |
| Initial Penalty |
2173.0 |
| Final Order |
2017-06-08 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.1053(b)(1): When portable ladders are used for access to an upper landing surface, the ladder side rails shall extend at least 3 feet (.9 m) above the upper landing surface to which the ladder is used to gain access; or, when such an extension is not possible because of the ladder's length, then the ladder shall be secured at its top to a rigid support that will not deflect, and a grasping device, such as a grabrail, shall be provided to assist employees in mounting and dismounting the ladder. In no case shall the extension be such that ladder deflection under a load would, by itself, cause the ladder to slip off its support. Four employee used an extension ladder which was only two feet over the upper landing surface and were exposed to falls up to 7 feet 11 inches to a lower level. |
|
| Citation ID |
02001 |
| Citaton Type |
Repeat |
| Standard Cited |
19260501 B13 |
| Issuance Date |
2017-05-16 |
| Current Penalty |
0.0 |
| Initial Penalty |
6518.0 |
| Final Order |
2017-06-08 |
| Nr Instances |
1 |
| Nr Exposed |
4 |
| Gravity |
5 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(13): Each employee(s) engaged in residential construction activities 6 feet (1.8 m) or more above lower levels were not protected by guardrail systems, safety net system, or personal fall arrest system, nor were employee(s) provided with an alternative fall protection measure under another provision of paragraph 1926.501 (b): Four employees were not protected by guardrails, safety nets, personal fall protection, or alternative fall protection measures under paragraph 1926.501, and were exposed to a 7 foot 11 inches fall to a lower level while conducting roofing operations. |
|
|
|
339401036
|
0524200
|
2013-09-05
|
684 PICKWICK CT., MOUNT PROSPECT, IL, 60056
|
|
| Inspection Type |
Referral
|
| Scope |
Partial
|
| Safety/Health |
Safety
|
| Close Conference |
2013-09-05
|
| Emphasis |
L: FALL
|
| Case Closed |
2014-03-24
|
Related Activity
| Type |
Referral |
| Activity Nr |
852015 |
| Safety |
Yes |
|
Violation Items
| Citation ID |
01001 |
| Citaton Type |
Serious |
| Standard Cited |
19260501 B13 |
| Issuance Date |
2013-10-02 |
| Abatement Due Date |
2013-10-15 |
| Current Penalty |
1400.0 |
| Initial Penalty |
2800.0 |
| Final Order |
2013-11-06 |
| Nr Instances |
1 |
| Nr Exposed |
1 |
| Gravity |
10 |
| FTA Current Penalty |
0.0 |
| Citation text line |
29 CFR 1926.501(b)(13): Each employee engaged in residential construction activities 6 feet or more above lower levels was not protected by guardrail systems, safety net systems, or personal fall arrest systems, nor did the employer demonstrate that it is infeasible or creates a greater hazard to use these systems and develop and implement a fall protection plan which meets the requirements of paragraph (k) of section 1926.502: a) Employee was performing roofing work and exposed to fall hazards of approximately 23.5 feet. In accordance with 29 CFR 1903.19(d), abatement certification is required for this violation (using the CERTIFICATION OF CORRECTIVE ACTION WORKSHEET), and in addition, documentation demonstrating that abatement is complete must be included with your certification. This documentation may include, but is not limited to, evidence of the purchase or repair of the equipment, photographic or video evidence of abatement, or other written records. |
|
|
